Results 1 to 8 of 8

Thread: Fuelling door won't open...

  1. #1

    Fuelling door won't open...

    Hi guys,
    Went to fill up today and the gas cap door is stuck in locked position. I tried locking/unlocking & turning ignition/car on and off a couple of times to no avail. Has anyone run into this before? (1993 500E)
    thanks in advance.

    Mark

  2. #2
    Site Honcho
    Klugscheisser
    Ich bekenne mich
    nicht schuldig.
    gerryvz's Avatar
    Join Date
    Nov 2008
    Location
    Annapolis, MD
    Posts
    18,330

    Re: Fuelling door won't open...

    There is an emergency release for the door on the inside of the fuel door vacuum element on the inside of the trunk, that will allow you to release the fuel door. It is likely that the vacuum element has failed, though it could be a vacuum supply issue as well. Best way to test it is with a MityVac or other handheld vacuum pump.

    Regards,
    Gerry

  3. #3

    Re: Fuelling door won't open...

    Thanks Gerry - that's great info. I will give it a go. Where's the Austin Powers pump when one needs it?

    Cheers
    Mark

  4. #4
    Site Honcho
    Klugscheisser
    Ich bekenne mich
    nicht schuldig.
    gerryvz's Avatar
    Join Date
    Nov 2008
    Location
    Annapolis, MD
    Posts
    18,330
    It should be a little red knob that you pull to move the vacuum element so that you can open the fuel flap.


    Sent from my iPad using Tapatalk HD

  5. #5
    E500E Guru emerydc8's Avatar
    Join Date
    May 2011
    Location
    Tucson, AZ
    Age
    53
    Posts
    1,363

    Re: Fuelling door won't open...

    N.B.: Be careful that you don't pull too hard. The red knob will break off.
    Jon D.
    1994 E420
    1995 E420

  6. #6

    Re: Fuelling door won't open...

    When I took the car to the dealer today for assessment, it was working again! It must have been just stuck. At least now I know where the emerg release knob is if it happens again.
    Thanks again guys - great resource!
    Mark

  7. #7
    Site Honcho
    Klugscheisser
    Ich bekenne mich
    nicht schuldig.
    gerryvz's Avatar
    Join Date
    Nov 2008
    Location
    Annapolis, MD
    Posts
    18,330

    Re: Fuelling door won't open...

    There's a good chance it may get "sticky" again. Sometimes the metal pin (see the lower part of the photo below) that moves up and down and actually "locks" the fuel door, rubs against the hole that it fits into and may get a little sticky. Either that or the rubber diaphragm inside the actuator is starting to fail. In any case, tt's a fairly inexpensive bit to replace, if necessary.

    Part number: 129 800 20 75

    AutohausAZ has the gen-u-whine MB part for around $58.00 + free shipping.

    Parts.com has it for $43.80 + probably around $8-10 shipping & handling (combine with other items to lessen shipping costs).

    Cheers,
    Gerry


  8. #8

    Re: Fuelling door won't open...

    Thanks Gerry - you the man! You are probably right - I am being overly optimistic. If it happens again, I'll replace it.

    Cheers. Mark

Similar Threads

  1. Replies: 42
    Last Post: 06-24-2013, 03:52 PM
  2. Replies: 4
    Last Post: 10-28-2012, 03:46 PM
  3. [OLD THREAD] How to open Trunk without key?
    By gerryvz in forum Troubleshooting and Diagnostics
    Replies: 0
    Last Post: 08-12-2011, 11:10 AM
  4. Door striker
    By josey_wales in forum Body Shop
    Replies: 1
    Last Post: 03-17-2011, 09:24 PM
  5. Open Classic Series. Circuito del Jarama, Madrid.
    By 500ESpain in forum Events, Meets and Get-Togethers
    Replies: 5
    Last Post: 05-14-2010, 04:53 PM

Bookmarks

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •